Give the Basis, Process Flow Diagram, Find, Solution. Spent Acid from a stripping column contains 23% H2SO4 and 77% H2O by mass. This stream is to be strengthened by adding concentrated sulfuric acid (94% H2SO4). If the ratio of the flowrate of the spent acid to that of the concentrated acid is 2:1, what is the percent composition of the product stream?

Q: A double effect evaporator is used to concentrate an 18% CuSO4 solution. At the end of the…

A: Aqueous solution of CuSO4 is concentrated in a double effect evaporator.

Q: 3. An evaporator is concentrating solutions from the two different sources. The solution from the…

A:

Q: 7 evaporators are connected in series, i.e., the concentrated product of the first one is fed to the…

A: Introduction   Chemical engineers refer to a multiple-effect evaporator as a device for effectively…

Q: Spent Acid from a stripping column contains 23% H2SO4 and 77% H2O by mass. This stream is to be…

A: Given  Percent composition of spent acid = 23% Percent composition of concentrated acid = 94 % And…

Q: A distillation tower has a feed of 500 mol /h. The composition in the feed is 70% mol benzene and…

A: The mass flow rate of the feed is to be converted into units of kg/h.

Q: Fruit juice at 30 °C containing total solids 5% concentrated through evaporator, single effect.…

A: Given:m˙p=3000kgh Initial concentration=0.05Final concentration=0.4Temperature at juice…

Q: Problem No 3: A material contains 75% water and 25% solid is fed to a granulator at a rate of 4000…

A:

Q: A huge amount of clean water at 78.98°F flowing past over a flat slab of solid CiH&O2. The velocity…

A: Given: Water flows over a flat slab at a velocity of V = 0.361 ft/s = 0.11 m/s       (Convert into…

Q: Gas at 30 °C and 1.4 atm is flowing through an irregular duct. To determine the rate of flow of the…

A: Given that- Basis flow rate of gas entering the duct= V m3/min (supposed) Tempearture of Gas,…

Q: Soybean oil will be obtained by extracting soybean seeds with pure hexane. The composition of mushy…

A: Note: SInce we are entitled to answer only 3 sub-parts, we'll answer the first three. Please…

Q: A liquid solution initially containing 60% by mol of acetone and 40% by mol of water was…

A: Given, The moels of the feed, F = 100 mol The mole fraction of acetone in the feed, xF = 0.6 The…

Q: . Q5:A continues distillation column processing a saturated vapor containing 40% A, 30% B, and 30% C…

A: - F: Feed rate (500 mol/h)- D: Distillate rate (top product, 200 mol/h)- B: Bottom rate (remaining…

Q: MAKE A PROCESS FLOW SHEET DIAGRAM IN PRODUCING ETHYL ACETATE BY AN ESTERIFICATION PROCESS Ethanol…

A: To make a PFD for producing ethyl acetate by the given esterification process

Q: A fruit juice processing plant has an evaporator that produces concentrated orange juice at the rate…

A:

Q: In a filtration experiment, the slurry in water at 25 °C was filtered through a plate and frame…

A:

Q: Q3: Acetone and ethanol are separated using a distillation column with a partial condenser and…

A: A mixture of acetone and ethanol is separated into a fractionating distillation column.

Q: 2. plata rate of 10,000 kg/hr, calculate the flowrate of the liquid quid leaving the unit, this…

A: A feed is sent into a mixer and followed by a calciner. There are two discharges from the calciner.…

Q: A semi-batch distillation unit is filled with 300 mol of a 80 mol% benzene-20 mol% toluene mixture.…

A:

Q: Suppose methanol is used as a fuel in the plant, calculate the specific enthalpy of the fuel at the…

A: Initial conditions of methanol are given as:   Final conditions of methanol are given as:

Q: 9 evaporators are connected in series, i.e., the concentrated product of the first one is fed to the…

A:

Q: For an industrial process where a large amount of heat is required, a large combustion chamber is…

A: Dear User! The question does not state the relative composition of benzene and methyl alcohol in the…

Q: One hundred kg/hr of a 50 wt% solution of solute C in solvent A is to be extracted at 25 °C in a…

A: Given = 100 Kg/h of a 50 wt% solution of solute CT = 25^cTo find = Number of counter current stages

Q: 3.1 A spent Acid from a stripping column contains 23% H2S04 and 77% H20 by mass. This stream is to…

A: Given spent acid contains 23% 0f H2SO4 and percent of water 77%  And concentrated sulfuric acid…

Q: Differential Equations: Mixing Problem A tank contains 200 liters of brine with 20 kg of salt in…

A: initial volume of brine =200 L initial amount of salt =20 Kg initial concentratio of salt =20…

Q: A continues fractionation column, operation at atmospheric pressure, is to be designed to separate a…

A: Given : A mixture of CS2 and CCl4 is separated in a distillation column.Mixture containing Overhead…

Q: A single effect evaporator is operating under the following conditions: Feed Flow rate, lb/h…

A: Single effect evaporator is used to concentrate the given feed solution.

Q: A solution containing 50 weight % methanol and remaining water at 300 K is admitted to a…

A:

Q: A mixture of benzene and toluene is fed to a distillation column at a rate of 1000 kg/h. The feed…

A: First, calculate the mass flow rates of benzene and toluene in the feed stream:Mass flow rate of…

Q: Q13:- It is desired to dilute a concentrated sulfuric acid solution containing 70 wt% H2SO4 of a…

A:

Q: It is desired to recover pure alcohol from a feed stream consisting of water and alcohol. Due to the…

A: Pure alcohol is recovered from the mixture of water-alcohol with the help of solvent benzene in an…

Q: I need a labeled process flow chart and a DOF analysis for this problem:  One way to make coal…

A: To handle this detailed problem, let's first outline a process flow chart and perform a degree of…

Q: 100. mol/hr of a mixture of hexane (60.0 % by mol) and acetone are fed into a flash drum and…

A: The objective of the question is to determine the total flow rates of both streams exiting the flash…

Q: A (fluid 1) at the rate of 145 Ib/min s heated 75 °F to 150 °F by another fluid (fluid 2) enters the…

A: Given: Fluid 1 is heated from; Tc1 = 75oF to; Tc2 = 150oF Using a fluid (2) from; Th1 = 215oF to;…

Q: A petroleum gas mixture containing 65% propane, 25% of propylene and 10% of butane (mole percent) is…

A:

Q: A synthesis gas consists of 64% hydrogen, 33% carbon monoxide, 2% oxygen and the remainder is…

A:

Q: 68%NaOH is to be concentrated in a triple effect evaporator to 16% NaOH.If equal amount of water is…

A: Assume a feed rate that will be the basis for this system. There are two streams which are vapor…

Q: An evaporator is concentrating solutions coming from three different sources. The first source…

A:

Q: Q2: 20 lit/min of liquid water is fed to an evaporation unit. Another stream of air and CO, mixture…

A: The flow rate and the composition of all the streams mention in the unit is to be calculated.

Q: A huge amount of clean water at 78.98°F flowing past over a flat slab of solid C7H6O2. The velocity…

A: Given that- Velocity of fluid (water), v =0.361 ft/s= 0.11 m/s length of slab, L=9.6 inch=0.244 m…