Acetic acid is hydrolysed in three stirred tank reactors operated in series. The feed flows to the first reactor (V = 1 lit) at a rate of 400 cm³/min. The second and third reactors have volumes of 2 and 1.5 litres respectively. The first order irreversible rate constant is 0.158 min¹.Calculate the fraction hydrolysed in the effluent from the third reactor

Q: A reactor and a condenser is used for the production of methanol as shown in the figure below.The…

A: The flow rate of the reactor outlet stream, nR,out = 450 mol/min Composition of the outlet stream:…

Q: Use material and energy balances to calculate the mass flow rates (tonnes/day) of Streams B, C, D,…

A: Mass flow rate and heat flows of stream are to be calculated.

Q: A mixture containing 31% benzene (B) and 69% toluene (T) by mass is fed to a distillation column. An…

A: Given: Feed flow rate, F = 4998.77 kg/h Composition of Benzene in feed, xB,F = 0.31 Composition of…

Q: A continuous reaction requires a steady flow rate of ethylene. Ethylene is supplied by a 60.9 L gas…

A: Given  : Volume of cylinder Initial pressure Final pressure Temperature

Q: A mixture of  34% benzene (B) and y% toluene (T) by mass is fed to a distillation column. An…

A: Given: Feed rate. F = 3000 kg/h Percentage of benzene in feed, xF(B)% = 34% Percentage of benzene in…

Q: (a) If wastewater leaves the plant at ṁ1 the treatment unit (i.e., ṁ5) and to the waste lagoon…

A: Given that: Waste water has Cr =5.15 % = 0.0515 Cr has to be removed = 95%= 0.95   Wastewater leaves…

Q: If the thermometer reads 15C (wet bulb temperature, T₁ = 15C), use the heat-mass transfer analogies…

A:

Q: 1. [Flow equalisation, effect of equalisation on BOD mass loading rate]. Consider the volumetric…

A:

Q: 3. A mixture of 10 wt% water and 90 wt% chloroform enters a gravity separator at the flow rate of 20…

A: It is given that a mixture of 10 wt% water and 90 wt% chloroform enters a gravity separator. Given…

Q: All % compositions in the following problem are by mass, unless otherwise noted. The flow-sheet of…

A: Draw the flow diagram for the process as follows:

Q: 1. The SA Water desalination plant in Lonsdale was officially opened in 2013 to assist with fresh…

A:

Q: A mixture of 10 wt% water and 90 wt% chloroform enters a gravity separator at the flow rate of 20…

A:

Q: A mixture of  34% benzene (B) and 66% toluene (T) by mass is fed to a distillation column. An…

A:

Q: Consider the block flow diagram of an ammonia (NH3) production plant shown below. The fresh feed to…

A: The limiting reactant is determined in the system. The moles of hydrogen consumed and remained is…

Q: A solution of Acetone in Water is to be extracted using Chloroform as the solvent. The feed is 1000…

A: feed F = 1000 kg/h  Acetone % in feed  xf=35 % =0.35  Pure solvent chloroform  % in feed Ys = 0…

Q: Consider the block flow diagram of an ammonia (NH3) production plant shown below. The fresh feed to…

A:

Q: Using a packed column, ammonia is absorbed from air to water. The incoming gas contains 6% NH3 and…

A:

Q: A mixture containing 45 benzene (B) and 55 toluene (T) by mass is fed to a distillation column. An…

A: Basis:100kmol of mixture.

Q: 10 000 kg of sugar beet containing 15% sugar (A) and 5% water (C) by mass will be extracted in a…

A:

Q: A fresh feed consisting of propanol (P, C3H7OH) and oxygen (O2) is mixed with a recycle stream…

A: Given data: Total inlet flow rate to the reactor = 295 mol/min Composition of propanol and oxygen in…

Q: Q6/ Breakfast cereal is being dried in a fluidized bed dryer in which the cereal moves roughly…

A: Breakfast cereal is dried using fluidized bed dryer with the help of air.

Q: A process to purify glycerine from 10% to 25% is composed of an extraction tower and a distillation…

A: The flow sheet of the process can be shown as below Let x, y be the flow rate of top and bottom…

Q: Determine the volume (liter) of pure water required to dilute the feed acid solution.

A:

Q: A 10% by weight NaOH solution is being used for a caustic washing process. In order to smooth the…

A: Given data- Fin = inlet flow rate = 1000 gal/hr Cin = inlet concentration = 10.5% by weight=105…

Q: theoretical number of racks, the actual number of racks, and the location of the

A:

Q: Part of a professor's work in her previous job involved boiling and condensing hydrocarbon mixtures.…

A:

Q: A phosphoric acid solution and an ammonia solution are provided through flow control valves to an…

A: The Preliminary Hazard Analysis (PHA) is carried out by using various cases for instance, No…

Q: Cereal is being dried in a dryer by air flowing countercurrent to the cereal (see flowchart below).…

A: Given: Moisture content (mass fraction) of various streams is as follows: Fresh air is 0.0082 Wet…

Q: It is intended to absorb benzene from an oil stream through a tower in contact with steam. The inlet…

A: The flow rate of the gas-phase on the solute-free basis is taken as Gs and that for the liquid phase…

Q: 1) A distillation column is used to separate 2000 kg/h of mixture containing 800 kg methanol (Mw =…

A:

Q: The feed to an ammonia synthesis reactor contains 25 mole % nitrogen and the balance hydrogen. The…

A:

Q: The primary process to currently make hydrogen is Steam Methane Reforming (SMR) of natural gas. This…

A: Given, reactor effluent molar flow rate is 100 kmol per hour. Given, reactor effluent contains 26.1…

Q: 1) Three components (A, B, C) enter a mixer (Mixer #1) at a flow rate of 100 kg/hr, with mass…

A: Note: Since we only answer 1 question, we’ll answer the first one. Please resubmit other question…

Q: onsider the block flow diagram of an ammonia (NH3) production plant shown below. The fresh feed to…

A:

Q: Q1. [6 marks] Distillation column used to separate benzene and toluene mixture are working under the…

A: Inlet Feed Rate= 1000 Kg/hr Feed: Benzene = 35% = 350 Kg Toluene = 100-35 = 65% = 650 Kg Distillate…

Q: . In the presence of 20,000 lb/h of air, an external gas stream is delivered into an air pollution…

A: External gas stream fed at rate = 10,000 lb/h presence of air in air pollution control device =…

Q: Fresh apple juice contains 71.2% water flowing at a mass flow rate of 210 kg/h. The fresh juice is…

A: Given: Juice contains 71.2 % water at 210 kg/h is concentrated in evaporator. 90 % of water entering…

Q: (i) Flux of oxygen gas in kgmol/s•m² and gmol/s·cm². (ii) Flux of propane gas in kgmol/s•m². (iii)…

A: Given that d = 5 mm = 0.005m Z =10 cm = 0.1 m Temp,T =298.15 k Total pressure ,P =1 atm PA1 = 0.06…

Q: Q3/ Potassium nitrate solution (F) containing 19 wt. % KNO3 are continuously fed to the process…

A:

Q: Consider the following flowchart where a reverse osmosis unit is used to desalinize scawater. A…

A: Overall mass balance 100=s3+s5 salt balance 0.05*100=(0.01*s3)+(0.1*s5)…

Q: Based on the figure below: One thousand kilograms per hour of a mixture containing equal parts by…

A:

Q: NASA has designed a standard rocket engine to use on their new Mars lunar rover. The engine burns…

A: